Transitmania 10 @Santa Pod 18th to 20th May 2018


1978 mk 1 camper

Post here camper and camper conversion related stuff!

Moderator: Luke

Re: 1978 mk 1 camper

Postby walt1984 » Sat Jul 30, 2016 4:34 pm

Started fitting the new split charge wiring this afternoon . Managed to get relay fitted under battery tray out of sight and wired up.
Also tested the night heater i bought as spares repairs. Image
Got a few neighbours asking what it was and what i was doing to landrover, they still looked confused when i said i just need some power.

Abit miffed coz ive got to go to a BBQ now and i know ill get bugger all done tomorrow.

Sent from my P330X using Tapatalk
"due to ever increasing work load the light at the end of the tunnel has been turned off!"
User avatar
walt1984
Transit Fanatic
Transit Fanatic
 
Posts: 2029
Joined: Wed Mar 31, 2010 8:17 pm
Location: Craven

Re: 1978 mk 1 camper

Postby walt1984 » Wed Aug 03, 2016 9:57 pm

Been slowly getting on with split charge upgrade and night heater install.
Heater inst finished because I'm waiting on a part turning up.
Tonight I managed to get the radio wired to the leasure battery and fit switch for 2 speed heater fan.

Pictures are abit poor because flash won't work when batterys low so had to use a torch.Imagehigh and low switch wired up.Image I used a mk345 resistor and used what would be 1 as the low. It still needs mounting but its too dark now.Image switch mounted in one of original holes.

Part of split charge wiring done at the weekendImageImageImage
Not a good picture of relay mounted under battery tray


Sent from my HTC One S using Tapatalk
"due to ever increasing work load the light at the end of the tunnel has been turned off!"
User avatar
walt1984
Transit Fanatic
Transit Fanatic
 
Posts: 2029
Joined: Wed Mar 31, 2010 8:17 pm
Location: Craven

Re: 1978 mk 1 camper

Postby walt1984 » Sun Aug 21, 2016 7:35 pm

Was in for test yesterday (Saturday morning) booked for 1st job at 8.came home late friday, slept in Saturday. Dashed out at 8 and battery was flat, jumped it off then on way to mot exhaust started blowing on drivers front pipe to manifold.
Got there at 8.15,one car on ramp another waiting, sat about had a brew till cars were gone then i gets "walt. Put y camper on ramp am off t pick a van up"
Had a nosy round, bolt missing off exhaust hanger, greased king pins and hand brake cables and oiled ujs.
Passed with a couple of advisorys . Image
Off to work after.
Today ive got eberspacher fitted, plumb and wired up, taxi heater plumbed and wired and split charge wiring connected.
All working
Image
Parked on kurb and ramps under wheels make it easier to work on. ImageImage
Wiring extended. Image
Temporary fuel tank. Image
Fair way taxi heater and dacia expansion bottle. Image
Just need a cap.

Sent from my P330X using Tapatalk
"due to ever increasing work load the light at the end of the tunnel has been turned off!"
User avatar
walt1984
Transit Fanatic
Transit Fanatic
 
Posts: 2029
Joined: Wed Mar 31, 2010 8:17 pm
Location: Craven

Re: 1978 mk 1 camper

Postby jonochap » Mon Aug 22, 2016 12:56 am

Looking good Walt and good news on the test :)


Sent from my iPad using Tapatalk
Owner of not so troubled puk :)
jonochap
Transit Fanatic
Transit Fanatic
 
Posts: 2660
Joined: Sat Jul 07, 2012 6:15 am

Re: 1978 mk 1 camper

Postby walt1984 » Mon Aug 22, 2016 7:22 am

Thanks jono.
Looks rough on top but its getting there underneath.

Sent from my P330X using Tapatalk
"due to ever increasing work load the light at the end of the tunnel has been turned off!"
User avatar
walt1984
Transit Fanatic
Transit Fanatic
 
Posts: 2029
Joined: Wed Mar 31, 2010 8:17 pm
Location: Craven

Re: 1978 mk 1 camper

Postby robbie.cee » Thu Aug 25, 2016 10:35 pm

Ello mate great work. Cutting out may be too retarded making fuel evaporate..my essex v6 did it. Red hot exhaust manifold and boiled fuel. Timed it up about 30 degrees using timing gun and was sweet after!
You'll want about 6 degrees btdc with vac advance pulled off dizzy and vac blocked
2.9i 24v cosworth v6 LSD now fitted and quad pipes out back

Had
X-Reg Mk5 150ps 3.0 ESSEX V6
MAKE IT FIT



RIP Kirk Bacon aka Eugene Speed
User avatar
robbie.cee
Transit Extremist
Transit Extremist
 
Posts: 9113
Joined: Sun Oct 31, 2010 6:46 pm
Location: Basildon, Essex, UK

Re: 1978 mk 1 camper

Postby walt1984 » Fri Sep 02, 2016 1:26 pm

Ill have to check timing.
Alternator had packed up on bank holiday weekend.
Struggled to find anywhere that stocked one or a marine mechanic.
Got home in day light, left old alternator with local motorised discounts telling them what its off and want to upgrade to a bigger output.
they rung up this morning saying that they can get a left handed alternator but it wont have the black plastic lucas cover on the back.
Not a problem.
We supply alot of these alternators to canal boat yards
Sounds good when can you get one?
We can get one for 4pm.
Great, how much? getting ready for a big shock
£45 plus vat. For a 65Amp alternator.
Will be better than the standard 27amp one just need a bigger wire.

Sent from my P330X using Tapatalk
"due to ever increasing work load the light at the end of the tunnel has been turned off!"
User avatar
walt1984
Transit Fanatic
Transit Fanatic
 
Posts: 2029
Joined: Wed Mar 31, 2010 8:17 pm
Location: Craven

Re: 1978 mk 1 camper

Postby walt1984 » Sun Sep 11, 2016 7:16 pm

Fitted new alternator just so camper can be run and moved.
The new 1300mm belt wouldnt fit but managed to prize old one on, must of stretched a little over time.
Old lucas plug fits in back but it also has a B+ post to connect too.
Had jump leads but thought id just try to see if it would start as it was faced into sun.
A few slow throws and it fired up
I know it has the leisure battery to run from but i dont think the mk7 would of driven 90miles through towns and villages, run with side lights on closure to home and the started 2 weeks later with a duff alternator.

Sent from my P330X using Tapatalk
"due to ever increasing work load the light at the end of the tunnel has been turned off!"
User avatar
walt1984
Transit Fanatic
Transit Fanatic
 
Posts: 2029
Joined: Wed Mar 31, 2010 8:17 pm
Location: Craven

Re: 1978 mk 1 camper

Postby robbie.cee » Fri Sep 16, 2016 6:19 pm

Sorry should have been 13° btdc for essex v6 (6° btdc pinto) for timing advance
2.9i 24v cosworth v6 LSD now fitted and quad pipes out back

Had
X-Reg Mk5 150ps 3.0 ESSEX V6
MAKE IT FIT



RIP Kirk Bacon aka Eugene Speed
User avatar
robbie.cee
Transit Extremist
Transit Extremist
 
Posts: 9113
Joined: Sun Oct 31, 2010 6:46 pm
Location: Basildon, Essex, UK

Re: 1978 mk 1 camper

Postby walt1984 » Thu Feb 22, 2018 4:58 pm

A long over due up date
Where did I get to.
Camper has been used but just no updates
January 2017 we had all the brakes off stripped cleaned and new pads
Exhaust stripped coz it was blowing again on drivers manifold.
Spring time the starter died so a new old stock replacement fitted
Around a month later the leasure battery died along with the starter battery ened up getting a jump of a Bentley fitted with a 6BT cummins engine.
A fully working hob unit came up now have hob and a gillie.
Mot time and the only fault really Was the cheap led bulbs in the rear lights
The said belt that had stretched over time to fit the new alternator stretched a little more and snapped one Friday night on route to a steam rallly luckily local autoparts was still open.

Work is needed this spring on the roof lights as they are leaking
After looking at bigger better mirrors that are in keeping with the look of the mk1s I've bought a reversing camera and hoping to hide the camera under the rear step

Went to the camper last weekend even with the choke stuck once it pulled fuel up it started and idled happy, not bad to say it's been stood since September.
Show season will be starting at the beginning of may and we're hoping by then it's free to tax and maybe test exempt but think it will still be going in for a quick once over.
"due to ever increasing work load the light at the end of the tunnel has been turned off!"
User avatar
walt1984
Transit Fanatic
Transit Fanatic
 
Posts: 2029
Joined: Wed Mar 31, 2010 8:17 pm
Location: Craven

Re: 1978 mk 1 camper

Postby rhinocharge » Sun Mar 04, 2018 6:41 pm

What a cracking camper van. Great to see! 8)
rhinocharge
Transit Aficionado
Transit Aficionado
 
Posts: 108
Joined: Thu Jan 25, 2018 4:03 pm

Re: 1978 mk 1 camper

Postby walt1984 » Tue Apr 10, 2018 9:53 pm

Taxed and it's now free after missing out last year by 22 days
Been talking to some landrover lads and they said I could of got free road tax done on the build date.
Learn something new everyday
"due to ever increasing work load the light at the end of the tunnel has been turned off!"
User avatar
walt1984
Transit Fanatic
Transit Fanatic
 
Posts: 2029
Joined: Wed Mar 31, 2010 8:17 pm
Location: Craven

Re: 1978 mk 1 camper

Postby transit tramp » Sun Apr 15, 2018 2:13 pm

Really enjoying this thread, looks great so far mate
transit tramp
Transit Fan
Transit Fan
 
Posts: 11
Joined: Thu Apr 12, 2018 10:08 am

Previous

Return to Camper vans and conversions



Who is online

Users browsing this forum: No registered users