70k engine from new not starting easy

[trnsitvanman]

RWD twin wheel tipper body 2.4 engine mk6 shape
70k engine from new
no codes been checked

so far changed injectors,battery,starter motor
it was starting fine but now in the morning sometimes will not
could it be electrical ?
dirty map sensor in exaust ?

any help would be apreciated
its a good friend of mine and we both baffled.

lloyd

[dumper]

Hi you need to put up model of van and have you had the codes read

[trnsitvanman]

have updated
It slipped my mind I quite old now and its late for Norfolk, they go to bed at 10pm

[knobby1]

have updated
It slipped my mind I quite old now and its late for Norfolk, they go to bed at 10pm

Is it the horrible 135ps TDCi Mk6..?

Lord Knobrot

[trnsitvanman]

will ask the owner on monday

[Altransit]

A shorted glowplug (or 2/3/4) can rob starting power from the battery. You could try pulling out the relay and see if it starts any better

[trnsitvanman]

will investage it cheers
will come back too

[trnsitvanman]

90t350 model

[trnsitvanman]

===PCM DTC P1563===
Code: P1563 - FIP requesting engine stop

Module: Powertrain Control Module

Diagnostic Trouble Code details

FIP requesting engine stop

The FIP has identified a fault that may cause damage to the engine

If any other DTCs are present address these first.

===END PCM DTC P1563===

===PCM DTC P1664===
Code: P1664 - FIP malfunction

Module: Powertrain Control Module

Diagnostic Trouble Code details

FIP malfunction

FIP timing chain tension

PCM

This DTC may be caused by :

PCM

FIP

===END PCM DTC P1664===

===PCM DTC P0335===
Code: P0335 - use CPS circuit fault

Module: Powertrain Control Module

Diagnostic Trouble Code details

use CPS circuit fault

Open Circuit

This DTC may be caused by :

Crankshaft position sensor

Sensor Previously disconnected.

* Ignore DTC P0335 unless DTC P0149, P0167 or P1666 is also present.

Signal shorted to ground or signal return.

===END PCM DTC P0335===

===CSM DTC None===
Successful DTC reading, no error codes found

Module: Security module

===END CSM DTC None===

===RCM DTC None===
Successful DTC reading, no error codes found

Module: Restraint Control Module

===END RCM DTC None===

===ABS DTC None===
Successful DTC reading, no error codes found

Module: Antilock braking system

===END ABS DTC None===

[winterheating]

have updated
It slipped my mind I quite old now and its late for Norfolk, they go to bed at 10pm

Is it the horrible 135ps TDCi Mk6..?

Lord Knobrot

Pardon

Horrible 135ps tdci. Mk6
Is it Opposite Day???

[trnsitvanman]

just cleared the codes
will check out what pops up next year

[winterheating]

The battery needs checking, flat battery will cause all them codes.....and not starting.