Transitmania 12 @Santa Pod 15th to 17th May 2020


Glow plug light on dashboard came on and van conked out

Use this section to post all specific Transit Connect topics and questions

Glow plug light on dashboard came on and van conked out

Postby coffee_king » Mon Aug 19, 2019 9:30 am

Hi Guys
I was driving my 2005 Transit Connect on Saturday when suddenly the glow plug light on the dashboard came on and the van conked out.
I was able to safely pull the vehicle to the side of the road. I then turned everything off and back on again and luckily the van started back up again and I was able to continue to onwards with my journey.
Any ideas what occurred? Do I need to replace the glow plug/s?
Thanks in advance.
Owning: Ford Transit Connect 2005 T200 SWB LX TDCi 90PS
Updated 25th Aug 2014: Parts currently wanted: None.
coffee_king
Transit Aficionado
Transit Aficionado
 
Posts: 207
Joined: Thu Dec 19, 2013 8:10 pm

Re: Glow plug light on dashboard came on and van conked out

Postby Kenton » Sat Aug 24, 2019 10:23 pm

The cause of this for me was knackered injectors. Has the van been running ok lately? Any problems with lumpy running on cold starts?
2005 T230 LX 90 TDCi LWB
ST 17" alloys Toyo Proxes
Focus ST170 front seats
Fiesta Zetec S/W & G/K
Mondeo Inner Door handles & vents
Bonnet wrap
Side bars
2012 rear light clusters
Lined & carpeted
Lowered
Blacked H/lights
De-Cat pipe
User avatar
Kenton
Transit Aficionado
Transit Aficionado
 
Posts: 220
Joined: Thu Feb 05, 2015 10:09 am
Location: Surrey

Re: Glow plug light on dashboard came on and van conked out

Postby coffee_king » Sun Aug 25, 2019 11:45 am

Thanks for the reply. An auto electrician friend of mine ran his diagnostics tool on the van and said there was an error that replacing the CAMSHAFT POSITION SENSOR would fix.
Ive done that and the error has cleared now.

I have been told previously that an injector has probably gone on the van though as it sounds like its missing on tick over, but I was told it probably wasnt worth fixing when I was advised a few months ago.
So do you think this could still be an issue then?
Owning: Ford Transit Connect 2005 T200 SWB LX TDCi 90PS
Updated 25th Aug 2014: Parts currently wanted: None.
coffee_king
Transit Aficionado
Transit Aficionado
 
Posts: 207
Joined: Thu Dec 19, 2013 8:10 pm

Re: Glow plug light on dashboard came on and van conked out

Postby Kenton » Sun Aug 25, 2019 3:47 pm

No worries. To be honest, time will tell now. My injectors did not show up an error as such, so because injectors are rip-off expensive, i replaced the cam sensor to see if that would cure it, as this CAN also be a similar symptom, but it didn't fix my problem. By then we were more or less sure it was the injectors. I took the van to a diesel specialist, and they confirmed the injectors were all over the place and needed urgent replacement. Since replacing them for re-cons, starting and driving has been a pleasure once again - cold or hot.

All the best with this mate.
2005 T230 LX 90 TDCi LWB
ST 17" alloys Toyo Proxes
Focus ST170 front seats
Fiesta Zetec S/W & G/K
Mondeo Inner Door handles & vents
Bonnet wrap
Side bars
2012 rear light clusters
Lined & carpeted
Lowered
Blacked H/lights
De-Cat pipe
User avatar
Kenton
Transit Aficionado
Transit Aficionado
 
Posts: 220
Joined: Thu Feb 05, 2015 10:09 am
Location: Surrey

Re: Glow plug light on dashboard came on and van conked out

Postby coffee_king » Tue Aug 27, 2019 10:33 am

Thanks for your response, its much appreciated.
Whats the best case / worst case scenario here?
Glow plug light comes on again at some point during a drive, it conks out and I should always just be able to restart it, or it will just end up NOT being able to be restarted?
Owning: Ford Transit Connect 2005 T200 SWB LX TDCi 90PS
Updated 25th Aug 2014: Parts currently wanted: None.
coffee_king
Transit Aficionado
Transit Aficionado
 
Posts: 207
Joined: Thu Dec 19, 2013 8:10 pm

Re: Glow plug light on dashboard came on and van conked out

Postby Kenton » Tue Sep 03, 2019 7:33 pm

Sorry for the absence mate. IF yours is suffering with the same problem as mine had, then it WILL happen again, and the gaps between will become shorter. I just wanted it sorted, and knew it would only get worse. But is SHOULD continue to restart. My best advice by far would be to take it to a diesel specialist and have it diagnosed 100%. It will cost you for the diagnosis of course, but you will then know for certain what exactly is causing the cut outs. My money would err on the side of the injectors, as it sounds remarkably similar to my injector symptoms.
All the best mate! Sorry again for the radio silence
K
2005 T230 LX 90 TDCi LWB
ST 17" alloys Toyo Proxes
Focus ST170 front seats
Fiesta Zetec S/W & G/K
Mondeo Inner Door handles & vents
Bonnet wrap
Side bars
2012 rear light clusters
Lined & carpeted
Lowered
Blacked H/lights
De-Cat pipe
User avatar
Kenton
Transit Aficionado
Transit Aficionado
 
Posts: 220
Joined: Thu Feb 05, 2015 10:09 am
Location: Surrey

Re: Glow plug light on dashboard came on and van conked out

Postby coffee_king » Wed Sep 11, 2019 9:49 am

Cheers pal. I'll keep my eye on it for a while. It is running a bit rough and Ive been told previously (Over the phone) by an independent Ford specialist garage that no doubt an injector has gone.
Thanks for your advise.
Owning: Ford Transit Connect 2005 T200 SWB LX TDCi 90PS
Updated 25th Aug 2014: Parts currently wanted: None.
coffee_king
Transit Aficionado
Transit Aficionado
 
Posts: 207
Joined: Thu Dec 19, 2013 8:10 pm

Re: Glow plug light on dashboard came on and van conked out

Postby Kenton » Thu Sep 12, 2019 5:12 pm

No worries pal. Keep us updated!
K
2005 T230 LX 90 TDCi LWB
ST 17" alloys Toyo Proxes
Focus ST170 front seats
Fiesta Zetec S/W & G/K
Mondeo Inner Door handles & vents
Bonnet wrap
Side bars
2012 rear light clusters
Lined & carpeted
Lowered
Blacked H/lights
De-Cat pipe
User avatar
Kenton
Transit Aficionado
Transit Aficionado
 
Posts: 220
Joined: Thu Feb 05, 2015 10:09 am
Location: Surrey


Return to Transit Connect



Who is online

Users browsing this forum: No registered users